Nearly Insane Quilt - Block 41, Basket Block

Apple Patchwork Fabric - Nearly Insane Block 41

How cute is this apple fabric?  I recently picked it up as a remainder fat quarter at Country Threads in Bath.  It is not strictly the red and cream scope of my Nearly Insane Quilt, as it has a tiny bit of green and yellow in it, but I thought it would add some 'character'. 
Block 41 is a fairly traditional patchwork Basket Block, so I thought I would pair this up with the Minick and Simpson "Christmas Past" red spotty fabric that I have talked about in the past, to make this block an 'Apple Basket'. I have added a 10 pence coin to give some scale to the finished 6 inch block.


Block 41 - Traditional Basket Block, Nearly Insane Quilt

Here are the 31 paper pieces that make up this block, plus the handle of the basket which is an appliqued bias strip.

Block 41 Nearly Insane Quilt - Basket Block

You will see that during the construction of this English Paper Pieced block the incremental growth of the strip due to the fabric being wrapped around the paper, meant that I had to fit a 4 5/16" strip of half square triangles onto a 4" plain strip.

English Paper Piecing

The easiest way I have found to counter this is to level up the ends and start sewing (Stage 1).  By fixing the two pieces together at the beginning, you can then start to manipulate the two pieces, so that they are eventually a perfect match.

Stage 1

Once they are fixed by a few stitches, I then bend the two pieces around my fingers, with the longest edge on the outside.  Like a race track, the outer piece has to travel further than the inner piece, and with a bit of a 'jiggle', you can get them to line up (Stage 2).  For further accuracy, because the fabric is on paper, the paper can be folded in half, and I tend to use the sharp creases as markers to match up as you fit the two edges together.

Stage 2

Always check it as you are going along, unfolding the seam to adjust, giving it a tug here and there to ensure that there will be no overlap at the end (Stage 3).  It is easier to adjust just a few stitches that the full length of the seam.

Stage 3

At the end, the two edges of the pieces should be sewn together with no overlap.  As you can see from the picture below, the end result has a bit of a bend in it.  

English Paper Piecing - Block 41, Nearly Insane Quilt

Never fear.  In this situation I tend to give the joined piece a good steam with the iron.  Also, at the moment the pieces are being held rigid by the paper, once they are finally removed, the shape of the block will be fixed by the sashing, and it will then be able to relax and mould itself into place.  This technique works for me, but probably only because I am confident that the papers will keep the shapes accurate. I know there are some 'corkers' coming up where the half square triangles are half the size of these, and there are many more of them. I think I will just take each block at a time.


Basket Block 41, Nearly Insane Quilt

I built up the block for piecing into smaller blocks, but this was not before I had added the bias strip basket handle, which I appliqued onto the large triangle.  I make my bias binding using a cheap and clever technique I picked up at a Sandie Lush Applique Workshop at Busy Bees Patchwork in Newport.

Folding Bias Binding using a Pin and Ironing Board

I cut my bias strip 1" wide, for a 1/2" wide handle on my basket block handle.  To set the width of the bias strip, I secure a pin to the ironing board, with a 1/2" gap, which I then feed the folded bias strip through, pressing as I go.  By adjusting the pin you can make a bias strip of any width.

Attaching bias strip for handle

I sewed on the bias strip with the paper still inside, and following the line on the paper which was visible through the spotty fabric.  Then, when I sewed the two halves of the block together, I hid the ends of the strip in the seam. 
This seems like quite an epic post for this unassuming block, but once I worked out what I was doing, this block was not too bad.  I know this block also makes up some of the edge blocks, so down the line maybe I will have a 'Cherry basket' too!

With another block finished, this Friday I am joining up with Crazy Mom Quilts.

NUMBER OF PIECES: 31 + 1 (Handle)
DIFFICULTY: 5/10
SMALLEST PIECE: Triangle, 1" (25mm) x 1" (25mm) x 1 7/16"" (36mm)
LARGEST PIECE: Triangle, 5" (127mm) x 5" (127mm) x 7 1/16"(180mm)
TECHNIQUE: English Paper Piecing (EPP)
FABRICS:
"Christmas Past" (14547) by Polly Minick and Lauri Simpson for Moda
Apple Fabric - unidentified
Red Dot on Cream - unidentified